您好,欢迎光临!莱州聚峰机械有限公司网站!

莱州聚峰机械有限公司

定制咨询热线:400-879-1999

行业新闻

首页>>资讯中心>>行业新闻混凝土搅拌车深化保养需要注意什么?
联系我们
莱州聚峰机械有限公司

联系人:刘经理

电话:400-879-1999

地址:山东省莱州市206国道与308省道交叉口东南50米

混凝土搅拌车深化保养需要注意什么?

来源:https://www.zishangliaojiaobanji.cn 日期:2021-01-25 发布人:admin
概述:一、混凝土搅拌车润滑系统的深化保养,搅拌车每行驶5000km-10000km时就需清洗保养一次,在遇到搅拌车发动机噪音过大,加速无力,水温过高时
一、混凝土搅拌车润滑系统的深化保养,搅拌车每行驶5000km-10000km时就需清洗保养一次,在遇到搅拌车发动机噪音过大,加速无力,水温过高时也需清洗保养一次。
1、 For the in-depth maintenance of the lubrication system of the concrete mixer, the mixer needs to be cleaned and maintained every 5000km-10000km. When the engine noise of the mixer is too loud, the acceleration is weak, and the water temperature is too high, it also needs to be cleaned and maintained once.
二、小型搅拌车燃油系统的清洗保养,也就是常在服务站看见的清洗喷油嘴,清洗节气门积炭,常规情况下,搅拌车每行驶10000km-15000km时需清洗保养1次,或当你发觉搅拌车的引擎喘抖,迟滞和加速不良,冒黑烟,无力、费油时清洗保养1次。
2、 The cleaning and maintenance of the fuel system of the small mixer is often seen in the service station to clean the fuel nozzle and clean the carbon deposit on the throttle. Under normal circumstances, the mixer needs to be cleaned and maintained once every 10000km-15000km, or once when you find that the engine of the mixer is panting, sluggish, poor acceleration, black smoke, powerless and fuel consuming.
三、搅拌车冷却系统的清洗保养,一般情况下,搅拌车在冬夏换季时应清洗保养一次,正常行驶中每6个月8个月清洗保养一次,或者遇水温过高、漏水、开锅时清洗保养一次。
3、 Generally speaking, the mixer cooling system should be cleaned and maintained once in winter and summer. During normal driving, it should be cleaned and maintained once every 6 to 8 months, or once in case of high water temperature, water leakage or boiling.
自上料搅拌车
四、混凝土搅拌车变速箱的清洗保养(自动变速波箱),常规情况下,搅拌车每行驶20000km-25000km时清洗保养一次,或遇变速箱打滑、水温偏高、换挡迟缓、系统渗漏时清洗保养一次。
4、 For the cleaning and maintenance of the gearbox of concrete mixer (automatic gearbox), under normal circumstances, the mixer should be cleaned and maintained once every 20000km-25000km, or once in case of gearbox slipping, high water temperature, slow shift and system leakage.
五、小型搅拌车动力转向系统的清洗保养,搅拌车每行驶40000km-45000km清洗需保养一次,或遇转向困难系统渗漏,更换动力转向机配件后,也须清洗保养一次。
5、 For cleaning and maintenance of power steering system of small mixer truck, cleaning and maintenance shall be carried out once every 40000-45000km, or in case of leakage of steering difficulty system, cleaning and maintenance shall also be carried out once after replacement of power steering gear accessories.
六、混凝土搅拌车制动系统的清洗保养,搅拌车每行驶50000km清洗保养一次,或遇ABS反应过早,过慢时清洗保养一次。系统中有害的油泥漆膜,超高温或超低温时工作失灵的危险,有效防止搅拌车制动液变质过期,彻底更换旧的制动液。
6、 For the cleaning and maintenance of the brake system of concrete mixer, the mixer should be cleaned and maintained every 50000km, or when the ABS reaction is too early or too slow. Remove the harmful oil sludge paint film in the system, remove the danger of working failure at ultra-high temperature or ultra-low temperature, effectively prevent the deterioration and expiration of the mixer brake fluid, and completely replace the old brake fluid.
精彩的内容不多,看到就赶快收藏吧!自上料搅拌车为大家推送精彩的内容,请大家关注我们的网址:https://www.zishangliaojiaobanji.cn,值得!
There are not many wonderful contents. Please collect them as soon as you see them! Since the feeding mixer for you to push wonderful content, please pay attention to our website: https://www.zishangliaojiaobanji.cn It's worth recommending!

阅读/ Recommended reading

小型混凝土搅拌机生产效率高,搅拌质量好,操作简单,重量轻,自动化程度高,操作方便、移动方便、生产效率高等优点,所以使用的人是越来越

解析小型搅拌机的结构及各部分功... 2022-12-21
小型搅拌机整体生产效率受影响的... 2022-12-19
自上料搅拌车的罐体内部部件剖析 2022-12-16
自上料搅拌车离合器活塞密封性的... 2022-12-14
搅拌车结构会根据不同的路况进行... 2022-12-05
利用光照法观察搅拌机机油颜色是... 2022-12-02
混凝土搅拌机的常见三大故障 2022-11-30
自上料搅拌车预防漏油的六大措施 2022-11-28

截屏,微信识别二维码