您好,欢迎光临!中科聚峰机械有限公司网站!

莱州聚峰机械有限公司

定制咨询热线:400-879-1999

行业新闻

首页>>资讯中心>>行业新闻>>搅拌机出现黑白烟雾的应对
联系我们
莱州聚峰机械有限公司

联系人:刘经理

电话:400-879-1999

地址:山东省莱州市206国道与308省道交叉口东南50米

搅拌机出现黑白烟雾的应对

来源:https://www.zishangliaojiaobanji.cn 日期:2022-06-01 发布人:zhongke
概述:搅拌机的冒烟问题有大有小,尤其是搅拌机车主遇到这个问题总是不知所措,担心自己的搅拌机不小心被损坏掉。其实,不同颜色的烟雾有不同的问
搅拌机的冒烟问题有大有小,尤其是搅拌机车主遇到这个问题总是不知所措,担心自己的搅拌机不小心被损坏掉。其实,不同颜色的烟雾有不同的问题,但总有办法应对。下面来简答讲一讲吧。
The smoke problem of the mixer varies greatly, especially when the mixer locomotive owner encounters this problem, he is always at a loss for fear that his mixer will be damaged accidentally. In fact, different colors of smoke have different problems, but there are always ways to deal with them. Let's talk about it briefly.
黑烟:
Black smoke:
小型搅拌机启动时,发动机振动很大,排气管声音正常,同时还有黑烟。当车辆加速时,感觉很弱。分析:一般来说,冒黑烟的主要问题是化油器。汽油进入气缸后,会因长时间在车外排气而产生黑烟排放问题。
When the small mixer is started, the engine vibrates greatly, the sound of the exhaust pipe is normal, and there is black smoke. When the vehicle accelerates, the feeling is very weak. Analysis: Generally speaking, the main problem of black smoke is the carburetor. After gasoline enters the cylinder, it will exhaust outside the vehicle for a long time, resulting in black smoke emission.
一般来说,带化油器的车辆都是老一代车,所以这类车要经常检查化油器等零部件的老化程度。对于带化油器的车辆,每30000公里检查一次气缸线,每10000公里检查一次火花塞。如果发现问题,需要及时更换。
Generally speaking, vehicles with carburetors are of the older generation, so the aging degree of carburetor and other parts should be checked frequently. For vehicles with carburetor, check the cylinder line every 30000 km and the spark plug every 10000 km. If any problem is found, it needs to be replaced in time.
白烟:
White smoke:
有时会发现即使在发动机暖机后,仍有大量白蒸汽存在,通常称为白烟。
It is sometimes found that even after the engine is warmed up, there is still a large amount of white steam, which is usually called white smoke.
分析:大部分白烟可能是由于小型搅拌机发动机气缸的气缸垫磨损造成的,产生了一定的间隙,让冷却系统中的大量水进入燃烧室。水不能烧。当燃烧室温度较高时,水会变成蒸汽直接从排气管排出,产生白烟。
Analysis: most of the white smoke may be caused by the wear of the cylinder gasket of the engine cylinder of the small mixer, resulting in a certain gap, allowing a large amount of water in the cooling system to enter the combustion chamber. Water cannot be boiled. When the temperature of the combustion chamber is high, the water will turn into steam and be directly discharged from the exhaust pipe, producing white smoke.
小型搅拌机
检查发动机缸体、缸盖垫片是否损坏,检查油箱内是否有水;二是查看汽车说明书,严格按照厂家规定加贴正确标签的汽油。
Check whether the engine cylinder block and cylinder head gasket are damaged and whether there is water in the oil tank; Second, check the vehicle manual and add gasoline with correct labels in strict accordance with the manufacturer's regulations.
所以就需要车主在开机前后做好相关的检查工作了,比如清理现场,检查搅拌叶、绞刀的角度,离合器应处于分立状态;检查各部位紧固螺栓是否紧固,各部润滑是否已经加到适量润滑油;若发现异常响声、怪味或发生烟雾时,要停机切断电源;检查搅拌设备,保持传动护照的完好;断开设备的电源进线开关,做好记录。
Therefore, it is necessary for the owner to do a good job of relevant inspection before and after the startup, such as cleaning the site, checking the angle of the mixing blade and the cutter, and the clutch should be in a separate state; Check whether the fastening bolts of each part are fastened and whether the lubrication of each part has been added with an appropriate amount of lubricating oil; In case of abnormal sound, smell or smoke, shut down the machine and cut off the power supply; Check the mixing equipment and keep the transmission passport in good condition; Disconnect the power incoming switch of the equipment and make records.
搅拌机出现黑白烟雾的应对相关内容讲解完毕,您可以关注我们网站https://www.zishangliaojiaobanji.cn从中获取到更多使用设备工作的内容,给您大的参考度。
After the explanation of the relevant contents about how to deal with black and white smoke in the mixer, you can follow our website https://www.zishangliaojiaobanji.cn We can learn more about working with the equipment and give you a great reference.

推荐阅读/ Recommended reading

在使用小型混凝土搅拌机之后,用户非常烦躁清理滚筒内残留的混凝土,一旦干了就难以清理,这是用户很头疼的事情,有什么办法可快速清理滚

自上料搅拌机电路系统检查测量时... 2022-06-22
搅拌机的操作过程中要注意液压油... 2022-06-20
小型混凝土搅拌车的多项检查规定 2022-06-17
从维修角度看保养搅拌车注意的问题 2022-06-15
自上料搅拌车春季保养小贴士 2022-06-13
污物进入工作油液会引起搅拌机零... 2022-06-10
小型混凝土搅拌机轮胎的异常磨损... 2022-06-08
司机在搅拌机操作中需要注意的事情 2022-06-06

截屏,微信识别二维码