您好,欢迎光临!中科聚峰机械有限公司网站!

莱州聚峰机械有限公司

定制咨询热线:400-879-1999

行业新闻

首页>>资讯中心>>行业新闻>>小型混凝土搅拌车的多项检查规定
联系我们
莱州聚峰机械有限公司

联系人:刘经理

电话:400-879-1999

地址:山东省莱州市206国道与308省道交叉口东南50米

小型混凝土搅拌车的多项检查规定

来源:https://www.zishangliaojiaobanji.cn 日期:2022-06-17 发布人:zhongke
概述:小型混凝土搅拌车属于工业车辆,做好检验规程非常重要。接下来,我们来看看小型混凝土搅拌车需要遵守哪些检验规定。 Small concrete mixe
小型混凝土搅拌车属于工业车辆,做好检验规程非常重要。接下来,我们来看看小型混凝土搅拌车需要遵守哪些检验规定。
Small concrete mixer is an industrial vehicle, so it is very important to do well in inspection procedures. Next, let's take a look at the inspection regulations that small concrete mixers need to comply with.
搅拌筒框架缓冲部分不得有裂纹或损坏;搅拌筒内叶片、进料斗、主副出料溜槽不得有严重磨损和变形。
The buffer part of the mixing drum frame shall not be cracked or damaged; The blades, feed hopper and main and auxiliary discharge chute in the mixing drum shall be free of serious wear and deformation.
搅拌筒、进料斗、主副出料槽内不得有明显的混凝土结块。
There shall be no obvious concrete caking in the mixing drum, feed hopper and main and auxiliary discharge chute.
取力器工作时应平稳,压力应达到设计额定要求,不得有泄漏。
The power take-off shall be stable during operation, and the pressure shall meet the design rated requirements without leakage.
小型混凝土搅拌车液压系统部件齐全完好,系统工作压力符合说明书要求。
The hydraulic system components of the small concrete mixer are complete and intact, and the working pressure of the system meets the requirements of the manual.
液压油的种类、质量、数量和用途应符合有关规定;热泵油温不得超过80℃;管路连接应可靠;不得有腐蚀、变形、老化、损坏和漏油现象。
The type, quality, quantity and use of hydraulic oil shall comply with relevant regulations; The oil temperature of heat pump shall not exceed 80 ℃; Pipeline connection shall be reliable; There shall be no corrosion, deformation, aging, damage and oil leakage.
各液压控制部件动作灵活,连接可靠。
All hydraulic control components are flexible and connected reliably.
水泵及供水系统各部件齐全,无渗漏。
All components of water pump and water supply system are complete without leakage.
液压系统应配备安全装置,防止过载和液压冲击;安全泄压阀的调整压力不应大于液压泵的额定压力。
The hydraulic system shall be equipped with safety devices to prevent overload and hydraulic shock; The adjustment pressure of the safety relief valve shall not be greater than the rated pressure of the hydraulic pump.
小型混凝土搅拌车
搅拌车的后部和侧面保护装置应齐全。
The rear and side protection devices of the mixer shall be complete.
小型混凝土搅拌车应配备消防设备。
Small concrete mixer truck shall be equipped with fire fighting equipment.
严格规范是保证小型混凝土搅拌车安全使用的重要工作。希望您能按上述检查规定检查搅拌车辆,这样才能后期使用更顺利更安全。
Strict specification is an important work to ensure the safe use of small concrete mixer. We hope you can check the mixing vehicle according to the above inspection regulations, so that it can be used more smoothly and safely in the later stage.
此外搅拌车的驻车制动系统是作用在后轮上的,而因为后轮制动器的形式不同,驻车制动有两种工作环境:在安装鼓式制动器的后轮上,由于鼓式制动器本身就可以兼做驻车制动器,因此在驻车时刹车鼓内的蹄片和摩擦片相结合,这样就可以产生动力;而在安装蝶式制动器的后轮上,由于没有刹车鼓,因此就必须在刹车碟片的中心部位安装额外的驻车鼓来是驻车制动完成制动工作。
In addition, the parking brake system of the mixer truck acts on the rear wheels. Because the rear wheel brakes have different forms, the parking brake has two working environments: on the rear wheels with drum brakes, the drum brakes themselves can also act as parking brakes, so the shoes and friction pads in the brake drum are combined during parking, so power can be generated; On the rear wheel with butterfly brake, there is no brake drum, so it is necessary to install additional parking drum in the center of the brake disc to complete the braking work.
以上就是今天为大家分享的关于问题的相关内容,希望对大家能有所帮助,想要了解更多内容可以电话联系我们或者关注我们的网站https://www.zishangliaojiaobanji.cn
The above is the relevant content about the problem shared for you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website https://www.zishangliaojiaobanji.cn 。

推荐阅读/ Recommended reading

在使用小型混凝土搅拌机之后,用户非常烦躁清理滚筒内残留的混凝土,一旦干了就难以清理,这是用户很头疼的事情,有什么办法可快速清理滚

自上料搅拌机电路系统检查测量时... 2022-06-22
搅拌机的操作过程中要注意液压油... 2022-06-20
小型混凝土搅拌车的多项检查规定 2022-06-17
从维修角度看保养搅拌车注意的问题 2022-06-15
自上料搅拌车春季保养小贴士 2022-06-13
污物进入工作油液会引起搅拌机零... 2022-06-10
小型混凝土搅拌机轮胎的异常磨损... 2022-06-08
司机在搅拌机操作中需要注意的事情 2022-06-06

截屏,微信识别二维码