自上料搅拌机

24小时服务热线

400-879-1999

点击拨打服务热线:400-879-1999

自上料搅拌机资讯

首页>>资讯中心>>自上料搅拌机资讯>>使用自上料搅拌车驾驶者需要掌握哪些?

使用自上料搅拌车驾驶者需要掌握哪些?

来源:http://www.zishangliaojiaobanji.cn 日期:2020-10-26 发布人:admin
概述:1、自上料搅拌车应设置在平整的方位,用方木垫起前后轮轴,使轮胎搁高架空,避免在开动时发作走动。1 The self loading mixer should
1、自上料搅拌车应设置在平整的方位,用方木垫起前后轮轴,使轮胎搁高架空,避免在开动时发作走动。
1. The self loading mixer should be set in a flat position, and the front and rear axles should be padded with square wood to make the tires empty, so as to avoid moving when starting.
2、自上料搅拌车应施行级漏电保护,上班前电源接通后,有必要仔细查看,经空车试转以为合格,方可运用。试作业时应查验拌筒转速是否适宜,一般状况下,空车速度比重车(装料后)稍快2~3转,如相差较多,应调整动轮与传动轮的份额。
2. Grade leakage protection should be implemented for the charging mixer. After the power supply is connected before going to work, it is necessary to check carefully, and it can be used only after the empty car is tested as qualified. During the trial operation, it is necessary to check whether the speed of mixing drum is appropriate. Under normal conditions, the speed of empty truck is slightly faster than that of truck (after loading). If there is a large difference, the share of driving wheel and driving wheel shall be adjusted.
3、拌筒的旋转方向应契合箭头指示方向,如不符实,应更正电机接线。
3. The rotation direction of mixing drum shall be in accordance with the direction indicated by the arrow. If not, the motor wiring shall be corrected.
自上料搅拌车
4、查看传动离合器和制动器是否灵敏牢靠,钢丝绳有无损坏,轨迹滑轮是否杰出,周围有无妨碍及各部位的光滑状况等。
4. Check whether the transmission clutch and brake are sensitive and reliable, whether the wire rope is damaged, whether the track pulley is outstanding, whether there are obstacles around and the smoothness of various parts.
5、开机后,常常留意混凝土搅拌机各部件的作业是否正常。停机时,常常查看混凝土搅拌机叶片是否打弯,螺丝有否打落或松动。
5. After starting up, often pay attention to the concrete mixer parts of the operation is normal. When stopping the machine, often check whether the blade of the concrete mixer is bent and whether the screw is broken or loose.
6、当混凝土拌和结束或估计停歇1h以上,除将余料出净外,运用石子和清水倒入抖筒内,开机滚动,把粘在料筒上的砂浆冲刷洁净后悉数卸出。料筒内不得有积水,避免料筒和叶片生锈。一起还应整理拌和筒外积灰,使机械保持清洁无缺。
6. When the concrete mixing is finished or it is estimated to stop for more than 1 h, in addition to discharging the remaining materials, stone and water shall be poured into the shaking drum, and the machine shall be started to roll, and the mortar adhered to the barrel shall be washed and cleaned, and then all the mortar shall be discharged. There should be no water in the barrel to avoid rust of the barrel and blade. At the same time, the ash accumulated outside the mixing drum should be sorted out to keep the machinery clean.
7、下班后及停机不用时,应拉闸断电,并锁好开关箱,以确保安全。
7. After work and when the machine is not in use, the switch should be switched off and the switch box should be locked to ensure safety.
只有把上述所讲的内容设定好,我们的操作才算完成,如果您这边在后续的过程中有任何的问题,欢迎致电或者是在网站上边留言:自上料搅拌车https://www.zishangliaojiaobanji.cn
If you have any problems in the follow-up process, please call or leave a message on the website: self feeding mixer https://www.zishangliaojiaobanji.cn
此文关键词:自上料搅拌车

推荐阅读/ Recommended reading

多功能混凝土搅拌车若是出现故障的话,那么不是会对车辆本身造成危害,更重要的是搅拌车内的混凝土也会受到波及,若是混凝土因为多功能混凝

小型混凝土搅拌机常见的客户问答 2021-01-18
小型混凝土搅拌车的混凝土凝固怎... 2021-01-15
防止自动搅拌车我给您妙招 2021-01-13
自上料搅拌车六项操作主要事项 2021-01-11
小型混凝土搅拌车卸料注意事项 2021-01-08
如何让自上料搅拌车进行安全运转? 2021-01-05
自上料搅拌车噪音大容易出现故障... 2020-12-30
自拌混凝土搅拌车下雨天怎么注意? 2020-12-29

截屏,微信识别二维码

微信号:1234567

点击微信号复制,添加好友

 打开微信