自上料搅拌机

24小时服务热线

400-879-1999

点击拨打服务热线:400-879-1999

常见问题

首页>>资讯中心>>常见问题>>如何让自上料搅拌车进行安全运转?

如何让自上料搅拌车进行安全运转?

来源:http://www.zishangliaojiaobanji.cn 日期:2021-01-05 发布人:admin
概述:1、自上料搅拌车应设置在平整的方位,用方木垫起前后轮轴,使轮胎搁高架空,避免在开动时发作走动。1 The self loading mixer should
1、自上料搅拌车应设置在平整的方位,用方木垫起前后轮轴,使轮胎搁高架空,避免在开动时发作走动。
1. The self loading mixer should be set in a flat position, and the front and rear axles should be padded with square wood to make the tires empty, so as to avoid walking when starting.
2、自上料搅拌车应施行级漏电保护,上班前电源接通后,有必要仔细查看,经空车试转以为合格,方可运用。试作业时应查验拌筒转速是否适宜,一般状况下,空车速度比重车(装料后)稍快2~3转,如相差较多,应调整动轮与传动轮的份额。
2. The self feeding mixer shall be provided with class I leakage protection. After the power is connected before going to work, it is necessary to check it carefully. It can be used only after it is considered as qualified after the trial run of the empty truck. During the trial operation, it is necessary to check whether the rotation speed of the mixing drum is appropriate. Generally, the speed of the empty truck is slightly faster than that of the truck (after loading). If there is a large difference, the proportion of the driving wheel and the driving wheel should be adjusted.
3、拌筒的旋转方向应契合箭头指示方向,如不符实,应更正电机接线。
3. The rotation direction of the mixing drum should match the direction indicated by the arrow. If not, the motor wiring should be corrected.
4、查看传动离合器和制动器是否灵敏牢靠,钢丝绳有无损坏,轨迹滑轮是否杰出,周围有无妨碍及各部位的光滑状况等。
自上料搅拌机
4. Check whether the transmission clutch and brake are sensitive and reliable, whether the wire rope is damaged, whether the track pulley is outstanding, whether there are obstacles around and the smoothness of each part.
5、开机后,常常留意混凝土搅拌机各部件的作业是否正常。停机时,常常查看混凝土搅拌机叶片是否打弯,螺丝有否打落或松动。
5. After starting up, always pay attention to whether the operation of each part of the concrete mixer is normal. When the machine stops, often check whether the blade of concrete mixer is bent, and whether the screw is broken or loose.
6、当混凝土拌和结束或估计停歇1h以上,除将余料出净外,运用石子和清水倒入抖筒内,开机滚动,把粘在料筒上的砂浆冲刷洁净后悉数卸出。料筒内不得有积水,避免料筒和叶片生锈。一起还应整理拌和筒外积灰,使机械保持清洁无缺。
6. When the concrete mixing is finished or it is estimated to stop for more than 1 hour, in addition to removing the remaining materials, use stones and clean water to pour them into the shaking drum, start the machine and roll them, wash and clean the mortar adhered to the drum, and then unload them all. There shall be no water in the barrel to avoid rust of barrel and blade. In addition, the ash accumulation outside the mixing drum shall be sorted out to keep the machinery clean.
7、下班后及停机不用时,应拉闸断电,并锁好开关箱,以确保安全。
7. After work and when the machine is not in use, the switch should be turned off and the switch box should be locked to ensure safety.
以上自上料搅拌机就是给大家分享的内容了,想要了解更多的精彩内容请点击https://www.zishangliaojiaobanji.cn进入我们的网站,或者是搜索我们的关键词查找,我们会有更多的精彩内容与您分享!
The above from the feeding mixer is to share the content, want to know more wonderful content, please click https://www.zishangliaojiaobanji.cn Enter our website, or search our keywords, we will have more wonderful content to share with you!
此文关键词:自上料搅拌机

推荐阅读/ Recommended reading

首先:我们需要对需要喷绘安装的场地进行测量和现场调查First of all, we need to measure and investigate the installation si

防止自动搅拌车我给您妙招 2021-01-13
自上料搅拌车六项操作主要事项 2021-01-11
小型混凝土搅拌车卸料注意事项 2021-01-08
如何让自上料搅拌车进行安全运转? 2021-01-05
自上料搅拌车噪音大容易出现故障... 2020-12-30
自拌混凝土搅拌车下雨天怎么注意? 2020-12-29
混凝土自动上料搅拌车生产的条件 2020-12-25
小型搅拌机装置性能的介绍 2020-12-22

截屏,微信识别二维码

微信号:1234567

点击微信号复制,添加好友

 打开微信