您好,欢迎光临!莱州聚峰机械有限公司网站!

莱州聚峰机械有限公司

定制咨询热线:400-879-1999

常见问题

首页>>资讯中心>>常见问题小型混凝土搅拌机的日常操作事项
联系我们
莱州聚峰机械有限公司

联系人:刘经理

电话:400-879-1999

地址:山东省莱州市206国道与308省道交叉口东南50米

小型混凝土搅拌机的日常操作事项

来源:https://www.zishangliaojiaobanji.cn 日期:2021-06-30 发布人:admin
概述:一、混凝土搅拌机在使用前检查项目:1、 Inspection items of concrete mixer before use:1 检查搅拌机机身是否平稳。1 Check wh
一、混凝土搅拌机在使用前检查项目:
1、 Inspection items of concrete mixer before use:
1.检查搅拌机机身是否平稳。
1. Check whether the mixer body is stable.
2.叶片以及搅拌叶片支撑臂上的连接螺栓是否牢固。
2. Whether the connecting bolts on the blade and mixing blade support arm are firm.
3.上料架上连接的螺栓是否紧固。
3. Whether the connecting bolts on the feeding frame are tight.
4.水泵引水是否充足,管路是否畅通。
4. Whether the water pump has sufficient water diversion and whether the pipeline is unblocked.
二、混凝土搅拌机在使用后检查项目:
2、 Inspection items of concrete mixer after use:
1.清理搅拌筒内外,卸料门,料斗上的积灰,并用水冲洗干净。
1. Clean up the dust inside and outside the mixing drum, discharge door and hopper, and rinse with water.
2.料斗应停放在运输位置上,并将制动销插好,料斗内不能有杂物。
2. The hopper should be parked in the transportation position, and the brake pin should be inserted well, and there should be no debris in the hopper.
3.切断电源,锁好电气控制箱。
3. Cut off the power supply and lock the electrical control box.
4.对各润滑点适当的加注润滑油(脂)。
4. Add proper lubricating oil (grease) to each lubricating point.
5.应将供水系统内的存水全部排出。
5. All the water in the water supply system should be discharged.
小型搅拌机
三、混凝土搅拌机每周检查项目:
3、 Weekly inspection items of concrete mixer:
1.检查钢丝绳磨损情况并在其表明涂少许润滑油,钢丝绳磨损到一定程度后,应进行更换。
1. Check the wear condition of wire rope and apply a little lubricating oil on it. After the wire rope is worn to a certain extent, it should be replaced.
2.检查减速箱油面,油泵油量,检查各润滑部位的情况,往料斗滚轮轴承及滑轮轴承加注润滑油。
2. Check the oil level of the gearbox and the oil quantity of the oil pump, check the condition of each lubricating part, and add lubricating oil to the hopper roller bearing and pulley bearing.
3.供水装置要保持清洁,以免堵塞,对吸水阀检查清洗一次。
3. The water supply device should be kept clean to avoid blockage. Check and clean the suction valve once.
4.检查行程开关摇臂是否松动,如有松动应予必要调整。
4. Check whether the rocker arm of the travel switch is loose, and adjust it if necessary.
5.检查叶片连接螺栓,支撑臂连接螺栓是否松动酌情调整,叶片与筒壁间的间隙大间隙5mm并作必要的拧紧。
5. Check whether the connecting bolts of blade and support arm are loose and adjust them as appropriate. The clearance between blade and cylinder wall is 5mm and tighten it as necessary.
6.检查电气箱中接触器触头情况。
6. Check the contact condition of the contactor in the electrical box.
7.拧开放淤塞,检查轴端密封,作必要的调整修理和更换。
7. Open the blockage, check the shaft end seal, and make necessary adjustment, repair and replacement.
四、混凝土搅拌机定期检查项目:
4、 Regular inspection items of concrete mixer:
1.对卷扬提升制动器进行检查并作适当的调整。
1. Check and adjust the hoist brake properly.
2.对水泵,节流阀进行检查,是否有漏水现象。
2. Check the water pump and throttle valve for water leakage.
3.对开式齿轮进行检查涂抹润滑油并调整皮带松紧。
3. Check the open gear, apply lubricating oil and adjust the belt tightness.
4.检查叶片,衬板的磨损情况,并酌情更换。
4. Check the wear of blades and liners and replace them as appropriate.
今日就是小编给大家编写的小型搅拌机的相关知识,更多的精彩内容请点击我们的网站:https://www.zishangliaojiaobanji.cn,欢迎大家在网站留言,或者拨打电话沟通交流.
Today is Xiaobian's knowledge about small mixer. For more wonderful content, please click our website: https://www.zishangliaojiaobanji.cn Welcome to leave a message on the website or call to communicate

阅读/ Recommended reading

小型混凝土搅拌机生产效率高,搅拌质量好,操作简单,重量轻,自动化程度高,操作方便、移动方便、生产效率高等优点,所以使用的人是越来越

解析小型搅拌机的结构及各部分功... 2022-12-21
小型搅拌机整体生产效率受影响的... 2022-12-19
自上料搅拌车的罐体内部部件剖析 2022-12-16
自上料搅拌车离合器活塞密封性的... 2022-12-14
搅拌车结构会根据不同的路况进行... 2022-12-05
利用光照法观察搅拌机机油颜色是... 2022-12-02
混凝土搅拌机的常见三大故障 2022-11-30
自上料搅拌车预防漏油的六大措施 2022-11-28

截屏,微信识别二维码