自上料搅拌机

24小时服务热线

400-879-1999

点击拨打服务热线:400-879-1999

常见问题

首页>>资讯中心>>常见问题>>混凝土搅拌车的维护和修理应该注意什么?

混凝土搅拌车的维护和修理应该注意什么?

来源:http://www.zishangliaojiaobanji.cn 日期:2020-04-23 发布人:admin
概述:在日常维护方面,混凝土搅拌运输车除应按常规对汽车发动机、底盘等部位进行维护外,还必须做好以下维护工作:In terms of daily mainte
在日常维护方面,混凝土搅拌运输车除应按常规对汽车发动机、底盘等部位进行维护外,还必须做好以下维护工作:
In terms of daily maintenance, in addition to the routine maintenance of the motor, chassis and other parts of the truck, the concrete mixer truck must also do the following maintenance:
清洗混凝土搅拌筒及进出料口:
Cleaning concrete mixing drum and material inlet and outlet:
由于混凝土会在短时间内凝固成硬块,且对钢材和油漆有一定的腐蚀性,所以每次使用混凝土贮罐后,洗净粘附在混凝土贮罐及进出料口上的混凝土是每日维护必须认真进行的工作。
As the concrete will solidify into hard blocks in a short period of time, and has certain corrosiveness to steel and paint, it is necessary to clean the concrete adhered to the concrete storage tank and the inlet and outlet after each use of the concrete storage tank.
中科自上料搅拌车
其中包括:
These include:
a.每次装料前用水冲洗进料口,使进料口在装料时保持湿润;
a. Flush the feed port with water before each loading to keep the feed port wet during loading;
b.在装料的同时向随车自带的清洗用水水箱中注满水;
b. At the same time of loading, fill the cleaning water tank with water;
c.装料后冲洗进料口,洗净进料口附近残留的混凝土;
c. Wash the feed port after loading, and clean the residual concrete near the feed port;
d.到工地卸料后,冲洗出料槽,然后向混凝土贮罐内加清洗用水30—40L;在车辆回程时保持混凝土贮罐正向慢速转动;
d. After unloading at the construction site, wash the discharge chute, and then add 30-40l of cleaning water to the concrete storage tank; keep the concrete storage tank rotating forward and slowly when the vehicle returns;
e.下次装料前切记放掉混凝土贮罐内的污水;
e. Remember to discharge the sewage in the concrete storage tank before the next loading;
f.每天收工时彻底清洗混凝土贮罐及进出料口周围,保证不粘有水泥及混凝土结块。
f. At the end of each day, thoroughly clean the concrete storage tank and around the inlet and outlet to ensure that there is no cement and concrete caking.
此文关键词:自上料搅拌车,小型搅拌机,自上料搅拌机

推荐阅读/ Recommended reading

多功能混凝土搅拌车若是出现故障的话,那么不是会对车辆本身造成危害,更重要的是搅拌车内的混凝土也会受到波及,若是混凝土因为多功能混凝

小型混凝土搅拌机常见的客户问答 2021-01-18
小型混凝土搅拌车的混凝土凝固怎... 2021-01-15
防止自动搅拌车我给您妙招 2021-01-13
自上料搅拌车六项操作主要事项 2021-01-11
小型混凝土搅拌车卸料注意事项 2021-01-08
如何让自上料搅拌车进行安全运转? 2021-01-05
自上料搅拌车噪音大容易出现故障... 2020-12-30
自拌混凝土搅拌车下雨天怎么注意? 2020-12-29

截屏,微信识别二维码

微信号:1234567

点击微信号复制,添加好友

 打开微信