您好,欢迎光临!中科聚峰机械有限公司网站!

莱州聚峰机械有限公司

定制咨询热线:400-879-1999

常见问题

首页>>资讯中心>>常见问题>>搅拌车水箱漏水从几个方面进行检查
联系我们
莱州聚峰机械有限公司

联系人:刘经理

电话:400-879-1999

地址:山东省莱州市206国道与308省道交叉口东南50米

搅拌车水箱漏水从几个方面进行检查

来源:https://www.zishangliaojiaobanji.cn 日期:2022-08-03 发布人:zhongke
概述:自上料搅拌机司机朋友如在使用过程中发现水箱漏水的故障,可从以下几个方面进行检查,如果故障仍不能排除,则需将车辆送至专业维修厂家进行
自上料搅拌机司机朋友如在使用过程中发现水箱漏水的故障,可从以下几个方面进行检查,如果故障仍不能排除,则需将车辆送至专业维修厂家进行检修,必要时跟换水箱。
If a friend from the charging mixer driver finds a water tank leakage fault during use, he can check it from the following aspects. If the fault still cannot be eliminated, the vehicle needs to be sent to a professional maintenance manufacturer for maintenance, and the water tank should be replaced if necessary.
一、检查搅拌车水箱盖是否扣紧,如果因松动出现漏水故障,将水箱盖扣紧即可。
1、 Check whether the water tank cover of the mixer truck is fastened. If water leakage occurs due to looseness, fasten the water tank cover.
二、如果是水箱出现破损漏水的故障,则需要进行气体加压,以检测试漏水点,从而进行修复。
2、 If the water tank is damaged and leaking, gas pressurization is required to detect the water leakage point for repair.
三、打开搅拌车发起机机油的盖子,看有无机油乳化痕迹,假如则需更换发动机缸垫。
3、 Open the cover of the engine oil of the mixer truck starter to see if there is any traces of oil emulsification. If so, replace the engine cylinder gasket.
自上料搅拌机
四、假如是搅拌车在行驶过程中,由于汽车抖动过大,使水箱水管破裂发生漏水,如漏水处是1–2mm的孔洞时,可向水箱中加入一瓶水箱强力堵漏剂,便可排除故障。
4、 If the mixer truck is in the process of driving, because the car vibrates too much, the water pipe of the water tank breaks and leaks. If the leak is a 1-2mm hole, you can add a bottle of strong water tank plugging agent to the water tank to eliminate the fault.
五、如果水箱散热管漏水较严重,可将漏水的散热管从漏水处剪断,用涂上肥皂的棉花团堵住被剪断散热管,然后用钳子把被剪断的散热管头部夹扁再卷边压紧即可遏止漏水。
5、 If the radiator pipe of the water tank leaks seriously, you can cut the leaking radiator pipe from the leaking place, block the sheared radiator pipe with a cotton ball coated with soap, and then clamp the head of the sheared radiator pipe flat with pliers and then crimp it to stop the leakage.
六、如果搅拌车橡胶管接头漏水,可及时用螺丝刀将橡皮管接头卡子在橡皮管接头缠二道,然后用钳子拧紧。如橡皮管损坏,可用胶布把决裂之处包扎紧,暂时运用。
6、 If the rubber pipe joint of the mixer truck leaks, wrap the rubber pipe joint clip on the rubber pipe joint twice with a screwdriver in time, and then tighten it with pliers. If the rubber tube is damaged, wrap the crack tightly with adhesive tape for temporary use.
搅拌车水箱漏水从几个方面进行检查就是以上解说内容了,此外您在日常使用时建议多多检查以及保养,固定时间去维修,有利于设备的寿命提高,更多事项来网站https://www.zishangliaojiaobanji.cn看看吧。
The above explanation is to check the water tank leakage of the mixer from several aspects. In addition, you are suggested to check and maintain more in daily use, and repair it at a fixed time, which is conducive to improving the service life of the equipment. For more matters, please visit the website https://www.zishangliaojiaobanji.cn Take a look.

推荐阅读/ Recommended reading

自上料搅拌车卸料后,卸料门关闭,但没有关闭信号,导致程序不能运行,原因可能有哪几种呢?又可以怎么去检修呢?下面小编为您解说。 Since

小型搅拌机突然跳闸怎么维修 2022-09-30
小型混凝土搅拌机转不动是什么原因 2022-09-30
使用搅拌机发动机的注意以及定期... 2022-09-28
自上料搅拌车发动机的防暑技巧推荐 2022-09-23
自上料搅拌机的平安操作注意事项 2022-09-19
自上料搅拌车的特征有什么? 2022-09-17
小型混凝土搅拌机要进行正确的系... 2022-09-17
小型搅拌机的运行特点是怎样的? 2022-09-17

截屏,微信识别二维码